• Basic Knowledge for Van Owners

    Checking and adding fluids • Battery • Oil filter • Fuses • Wiper fluid


    Tools needed: Nada!

    BRAKE FLUID

    To check the brake fluid, open the driver’s door (yes, really):

    brake_fluid.1_ed.jpg

    Looking closer, here’s a view of the "window” to check the brake fluid level:

    brake_fluid.2_ed.jpg
    Add brake fluid by removing the black rubber cap. Use DOT 3 brake fluid. Use a funnel and go slowly. Wipe any spilled fluid up immediately.


    CHECK OR ADD OIL AND COOLANT

    First, lift the engine “hood” (under your driver’s seat). Yes, really.

    Here’s where it’s all found:

    importantenginethings_ed.jpg

    Here’s what it is:

    1 = Oil fill cap. Add oil here! Toyota calls for SAE 10W30 oil in the 3Y and 4Y van engines. Some vans may require a different oil; most do not. Fill to the “full” line on the dipstick. If you are changing the oil, Toyota says you will need 3.7 quarts or 3.5 liters to refill.

    2 = Location of the oil dipstick

    3 = Radiator cap, which is on the “filler neck”, NOT on the radiator (vans be different)!

    4 = Coolant overflow tank. On the passenger (fan shroud) side of the tank, there are molded lines saying “ADD” and “FULL”. It helps to place a flashlight on top of the coolant bottle before looking at the lines; that way the coolant level shows up great. You will still have to lean waaay over.

    If you are checking coolant, DO include a check at the radiator cap (but NOT if the van is hot; wait until it cools down). If there is a leak anywhere in the system, the coolant overflow bottle (4) can be full, but the system itself can become dangerously low on fluid. You should see coolant up to the top of the filler neck.

    If the coolant regularly disappears (that is, the van needs coolant added to the overflow more than around once a year) or there is little or no coolant visible at the filler neck, the van has a serious problem. Don’t put off investigating that!!!


    BATTERY • OIL FILTER • POWER STEERING FLUID • TRANSMISSION FLUID

    Open the slider door. Yes, really!

    find_oil_filter1_ed.jpg
    On 2nd generation (’86-’89) vans, slide the passenger seat forward first.
    On 1st generation (’84-’85) vans, the passenger seat doesn’t slide, so don’t try!

    find_oil_filter2_ed.jpg
    The left cover (that should have a plastic-headed wing nut, but might not) is the access for your oil filter, power steering fluid, and (on automatic vans), the tranny fluid dipstick.

    Also notice that behind the driver’s seat on the floor is another carpet flap hiding the cover for the battery!
    If your van is not too beat up and hasn’t been modified by previous owner(s), the battery location sticker is probably still present on the interior trim panel:

    battery_location_ed.jpg
    Get the largest battery that fits in the compartment — don’t mess around with puny batteries for the vans.

    This is a 5-speed van, so no tranny dipstick.

    find_oil_filter3_ed.jpg
    Toyota calls for Dexron® or Dexron II® automatic transmission fluid (ATF) in the vans' power steering fluid system (and, in fact, for every other Toyota I’ve owned). These have been superceded by Dexron III®. DO NOT use “power steering fluid”! DO NOT overfill!


    Here’s the transmission fluid dipstick on an automatic transmission van:

    auto_tran_dipstick_ed.jpg
    Toyota calls for Dexron II® automatic transmission fluid (ATF); this has been superceded by Dexron III®
    Add fluid, if necessary, with a loooong skinny funnel right into the dipstick tube.


    FUSE BOX

    Here’s your van’s fuse box, found in the area under the glove box:

    fusebox.1_ed.jpg

    Here it is with the main cover off. Notice the small covered portion on the right side …

    fusebox.2_ed.jpg

    And here’s what’s lurking under that small covered portion.

    fusebox.3_ed.jpg
    These two fuses are necessary to the van’s operation — THEY ARE NOT EXTRA FUSES!
    Notice that the correct amperage and purpose of each is noted on the small cover.


    And here’s the back (inside) of the main fuse box cover, telling you what should be where and why.

    fusebox.4_ed.jpg
    The upper arrow points to the REAL spare fuses.
    The lower arrow points to the very cool and effective fuse puller (thanks, Toyota!).


    WINDSHIELD WASHER FLUID

    Open the (rear) lift gate. Yes, REALLY!

    Here it is!

    rear_washer_fluid_ed.jpg

    On the 1984 vans ONLY, there is a separate reservoir in the front. Access by lifting the passenger side carpet:

    front_washer_fluid_ed.jpg


    Now, aren’t you glad you have one of these kewl and ingenious Toyota Vans?

    Comments or questions on these basics? Want to read about others' experiences and tips?
    Go HERE to the companion forum thread !!!
  • Recent Forum Posts

    pdgizwiz

    Re: Headlight Help Needed

    I renewed a pair of badly yellowed '91 headlights using a 3M kit (described better in the "a few questions" thread.)
    Here's a before/after shot.

    pdgizwiz 11-28-2021, 04:20 PM Go to last post
    pdgizwiz

    Re: A few questions

    Congrats on your purchase! While Previas are becoming increasingly rare, they are still amazing, unique, and worth maintaining, IMHO.

    Transmission - I suppose the best thing would be some kind...

    pdgizwiz 11-28-2021, 03:57 PM Go to last post
    Sullivan

    Thoughts on 3.0 1kz?

    Hey y’all. I stumbled across a 1995 4WD hiace with a 3.0 1kz turbo diesel.. price seems decent. the van looks like it’s in decent shape 135k miles. I’m just wondering if you guys have any input on...

    Sullivan 11-27-2021, 06:29 PM Go to last post
    89van

    Re: A few questions

    Hmm, I would love to try this on my '89 TV (Yes I know i have no business here on the Previa sections for the time being) but if it does fail my TV will be out of action to find a replacement be it...

    89van 11-27-2021, 05:17 PM Go to last post
    cascadiantree

    Re: rear bench seat and mounting brackets

    I pm’d you

    cascadiantree 11-26-2021, 10:52 PM Go to last post