Part numbers

[Gunflint]

Hi all.

It seems a lot of folks are active with their townies nowadays. I thought it would be cool to have a thread to keep track of the part numbers people have used successfully. Anything from windshield wipers to injection pumps. Maybe post the part numbers in a color other than black so they are easy to find in the posts. I'll start:

Timing Belt: Toyota 13568-69066

Fuel Filter: Fram 4922

Oil filter: Napa 1368
Fram PH6357

Thermostat: Toyota 90916-03046

Radiator Cap: Toyota 16401-64501

Hopefully this proves to be helpful!

Matt

[89TownAce]

Also compatible are:

Fuel Filter - Wix 33138

Oil Filter - Wix 51368

There's also a NAPA air filter that works with a .25" spacer under it, but I can't recall the #. I'll find it...

[adamh]

cyl Head gasket kit 04112-64263 (minus cyl head gasket !!)
cyl Head gasket 11115-64170-B0
cyl head bolt 90910-02097 (8 required for cyl head gasket change)
cyl head bolt 90910-02099 (10 required for cyl head gasket change)
timing belt tensioner pulley ADT37602 (jockey pulley)
main timing belt 5057XS (GATES)
glow plug DG216 (denso)
injector gasket 11177-64010 (used for injector )
washer,PCK,RIN 23654-64010 (used for injector)
oil pan #2, 12112-64051 (this is the large thin baffle plate pan between main sump pan and block)
cylinder head shims are 34.00mm Overall diameter , in the thickness you require
sump pan drain plug gasket 90430-12031
main oil seal for pump 90311-42026 (this is the seal which seals on the crank in the oil pump)
oil filter 90915-30002-8T
C7C gasket oil pan strainer 15149-64070 (between oil strainer and block)
gasket oil pump 15193-64022 (thin rubber oddly shaped o-ring type rubber for face of pump to block)
replacement rotor kit for oil pump 04151-64020 (literally just the rotors,no good if you have any excessive wear in your alluminium pump housing journal bores, inspect carefully)
full oil pump 15100-64042
exhaust manifold to cyl head gasket 17173-64080 (long rectangular gasket, multi layer steel (mls), with 4 rectangular exhaust port hole and many stud holes)
turbo elbow to manifold gasket 17278-64031 (square with 4 holes for studs and main large circular hole for exhaust gas)
turbo elbow to manifold studs 90116-10148 (4 required)
nuts for turbo elbow to manifold 90179-10094 (4 required)
Brake cylinder kit for rear wheels 04906-30080 (rebuild kit for drum cylinders, rubber seals and boots etc , does both sides, good buy)

[Danny]

Hey Guys!

Any of you know the part number for our air filters? I know the toyota part is 17801-54050, but I cannot find a Napa or Wix equivalent. Any help here would be awesome...Thanx!

-Danny-

[89TownAce]

Danny I used the Napa FIL 6225 air filter, but it's about 3/8" short so I bought a 1/4" thick sheet of foam rubber, cut donuts for the top and bottom as spacers. Works great.

[JDM VANMAN]

My TownAce is petrol/gas version so I use the OEM filter but here's some specs about the filter your looking for-

[Danny]

Hey JDM VANMAN! Many thanks for this! I'm going to do a little digging to see if I can find an equivalent size/spec filter and report back. Appreciate your time

My TownAce is petrol/gas version so I use the OEM filter but here's some specs about the filter your looking for-

[TheCrippler]

AIR FILTER: WIX 49241

its 1-2 mm off but looks like it will work

They had to order it at O'Reilly but said it would come in 1 day for $39

[TheCrippler]

I found a goldmine of parts on here. Maybe easier than hunting through Japanese auction sites for some?

https://parts.loc8apart.co.uk

[TheCrippler]

Original Glow plug for 2ct:Toyota 19850-64020

[gojamsgo]

Using the Japanese GS Yuasa battery that was in my van as a guide I was able to find what I think is pretty much an exact replacement at wall-Mart. The Everstart Maxx group 27. It's 810 CCA, and the dimensions are almost exactly the same.

[TheCrippler]

I want to replace some of the radiator hoses on my townace. Is there an easy way to look up all the part numbers? a good diagram? Are auction sites the best place to source these?

[JDM VANMAN]

Did you try inputting your chassis code on toyodiy?
Here's an example of CR30G-PEZX

[JDM VANMAN]

Oh man sorry it came out blurry it always does that off of that site.

[cusco-awd]

What are the fluid capacitys on the oil and coolant.

[bikeregg]

I found a site that has downloadable manuals at www.qualityservicemanual.com. The download process was a bit cumbersome but, for $19.99, you get an electronic Toyota service manual that covers the Ace vans and an excerpt that covers the diesel engines.

[bikeregg]

I found an air filter that works.

STP SA3902

It's just a tad short so I put a strip of insulating foam on the lid to make a good seal.

Has anyone found brake pads, shoes, rotors or drums in the US?

[nomoneymike1]

Here is a link to the 1C, 2C and 2C-T engine repair manual (online):

https://cardiagn.com/toyota-1c-2c-2c...ir-manual-pdf/

No part#s here but I thought would be useful anyway.

[denalidevo]

Danny at Vanlife Northwest (where I purchased my 1992 TownAce) replaces all his van radiator caps with this one: NAPA 7031695.

[nomoneymike1]

Also compatible are:

Fuel Filter - Wix 33138

Oil Filter - Wix 51368

There's also a NAPA air filter that works with a .25" spacer under it, but I can't recall the #. I'll find it...

Is the oil filter listed above for a 2C-T?